Kolpak Walk-In Freezer Not Freezing in Middleburg, FL
Freezer compartment stays above 0°F. Common causes: defrost thermostat, evaporator fan, sealed-system leak. We fix this on Kolpak walk-in freezers across Middleburg. Call before noon and there's a good chance of a same-day visit.
Why your Kolpak walk-in freezer is not freezing
Here's how not freezing typically presents on a Kolpak walk-in freezer: freezer compartment stays above 0°F. Common causes: defrost thermostat, evaporator fan, sealed-system leak. Nine times out of ten it comes down to evaporator fan not running. Left unaddressed, food or stock can spoil within hours.
Most likely causes
- Sealed-system refrigerant leak
- Blocked air vents between compartments
- A clogged defrost drain
- Defrost thermostat or heater failure
- Failed temperature sensor
Known Kolpak walk-in freezer weak points
- door gasket and hinge/closer wear
- evaporator coil icing and defrost faults
- condensing-unit compressor failures
- cam-lock panel joint misalignment and air gaps
Quick check — and when it's not DIY
The one self-check that's actually worth your time: confirm the thermostat setting, that the door seals fully, and that vents inside aren't blocked by over-packed items. Also, listen for the evaporator fan running when the door's closed, since a silent fan is a common first sign. Should that not clear it, it's usually a defrost heater, sensor, or sealed-system fault, and diagnosing those needs a multimeter and refrigeration training, not guesswork.
How we fix it
We trace the not freezing on your Kolpak walk-in freezer to its source instead of throwing parts at it. OEM parts are available through Welbilt and PartsTown; sealed-system refrigerant work requires an experienced technician. You approve a flat price up front, and the work is backed by our labour and parts warranty.
independent commercial service experienced with Kolpak walk-in coolers, freezers and refrigeration systems, not authorized by the manufacturer
What Middleburg homeowners say
on the First Coast
“They squeezed our Kolpak walk-in freezer in on a busy day and still showed up inside the window. Stood behind the warranty and used a real Kolpak OEM part, not a knockoff.”
“Same-day response — a tech was diagnosing the Kolpak walk-in freezer hours after I called. Fixed on the first visit — the flat price matched the quote exactly, no upsell.”
“The Kolpak walk-in freezer died mid-week and they had it sorted before I'd even rearranged my schedule. Genuine Kolpak part, flat price, and done in a single visit.”
Frequently asked questions
Do you charge for the estimate?
We charge $149 for a full diagnostic, credited to the repair if you proceed. No separate trip fee and no surcharges added later.
What if the same problem comes back?
We stand behind the work with a 1-year labour warranty and 6-month parts warranty — if it recurs in that time, we fix it again for free.
What's the price for a Kolpak walk-in freezer that is not freezing?
Typical costs for a Kolpak walk-in freezer that is not freezing land between $280–$1,495, parts and labour included. The $149 call-out is applied to the job and the quote is flat — no meter running.
How fast can you get to Middleburg?
Same-day is common in Middleburg. Our trucks run the area every day and emergency slots are held open for breakdowns that can't wait.
Get same-day service in Middleburg.
Flat-rate pricing, 1 year labour warranty, and fast dispatch.